Problems and Solutions

Problem: Acid level is deficient
Possible Cause: There may be a leak from the covering box or gas outflow because of over charging.
Solution: Check your charger or buy a new Mutlu battery

Problem: Low acid density (<1.240 kg/dm3) and difficulty on starting
Possible Cause: Inadequate charging, a hardware draining the electricity, short circuit
Solution: Charge your battery again, get your cars charging system checked (regulator, alternator, electric system)

Problem: High acid density (>1.240 kg/dm3)
Possible Cause: Battery has been added acid instead of pure water
Solution: Acid level should be decreased and replaced with pure water (shall be repeated if needed)

Problem: Difficulty on march starting, low voltage
Possible Cause: Battery is discharged, dead (loss on positive plates), problem in one of the cells or sulphation
Solution: If it is discharged battery can be charged again otherwise a new Mutlu Battery shall be purchased.

Problem: Excessive wear and tear on polar and connections
Possible Cause: Faulty electric system or polar connection
Solution: Tighten the connections or renew cleats if needed
 

Problem: Boiling in one or more cell during march start
Possible Cause: Failure in cells or loosened, gapped polar connection
Solution: Tighten the connections or renew cleats if needed, purchase a Mutlu battery if the problem continues

Problem: Easily and often discharged battery
Possible Cause: Charge level of the battery may be low, there may be a short circuit or sulphation (plates in the battery goes stiffen and turn to white)
Solution: Check the charging level of the battery or purchase a new Mutlu battery

Problem: Short life time
Possible Cause: Wrong battery selection, too much exposure to deep discharge or leaving the battery for too long in deep discharge mode.
Solution: Replace the battery with a higher capacity one, if this is not possible check periodically and charge when needed.

Problem: Battery getting hotter than normal during operation and excessive water loss
Possible Cause: Your car might be charging on a high voltage
Solution: Get your cars electric system, alternator checked

Problem: Explosion of the battery
Possible Cause: After charging gasses flared up because of static electric or short circuit causing explosion
Solution: Purchase a new Mutlu Battery

Problem: Battery not working
Possible Cause: Failure in the internal system of the battery or deep discharge
Solution: Purchase a new Mutlu Battery